P0420 on Acura: Symptoms, Causes & DIY Fix
Official technical diagnostic wire for fault code P0420 (P0420: Catalyst System Efficiency Below Threshold (Bank 1)) specifically affecting Acura vehicles (MDX, RDX, TLX, Integra, ZDX).
1. Symptoms of P0420 on Acura
When the Engine Control Module (ECM/PCM) on your Acura logs fault code P0420, drivers commonly observe:
2. Most Likely Causes on Acura
Historical warranty claims and technical repair bulletins for Acura point to the following failure distribution:
3. Step-by-Step DIY Repair Guide for Acura
Use a live-data scan tool. Downstream O2 sensor should show a steady voltage around 0.45V to 0.7V. If it fluctuates rapidly between 0.1V and 0.9V like the upstream sensor, the cat is not storing oxygen. on Acura vehicles (MDX, RDX).
Check exhaust manifold gaskets and flex pipes before the catalytic converter. Extra air entering exhaust false-triggers the P0420 code. on Acura vehicles (MDX, RDX).
If the sensor is sluggish or older than 100,000 miles, replace the downstream oxygen sensor first before condemning the expensive catalytic converter. on Acura vehicles (MDX, RDX).
Pour a designated catalytic cleaner (e.g. Cataclean) into 1/4 tank of fuel and drive 50 miles on the highway to burn off surface carbon deposits. on Acura vehicles (MDX, RDX).
If codes return after sensor replacement and cleaning, replace the catalytic converter with an EPA or CARB compliant unit. on Acura vehicles (MDX, RDX).
4. Acura P0420 FAQs
What causes code P0420 to trigger on a Acura?
On Acura vehicles, P0420 is most frequently caused by Catalytic converter internal substrate degraded or melted or Faulty Downstream Oxygen Sensor (O2 Sensor Bank 1 Sensor 2). Factory sensor degradation or wiring harness wear near the engine bay are common factors.
Can I safely drive my Acura with code P0420?
Yes for moderate distances, but vehicle will fail state emissions inspections. Given that P0420 carries a Medium severity rating on Acura vehicles, we advise performing diagnostic scanning via the OBD-II port before extended driving.
How much does it cost to fix P0420 on a Acura?
DIY replacement parts typically range between $400 - $1,800 (DIY: $150 - $400). If serviced at an authorized Acura dealership, expect an additional $120–$250 in professional labor based on their $130/hr hourly rate.