P0671 on Dodge: Symptoms, Causes & DIY Fix
Official technical diagnostic wire for fault code P0671 (P0671: Cylinder 1 Glow Plug Circuit Malfunction) specifically affecting Dodge vehicles (Charger, Challenger, Durango, Hornet).
1. Symptoms of P0671 on Dodge
When the Engine Control Module (ECM/PCM) on your Dodge logs fault code P0671, drivers commonly observe:
2. Most Likely Causes on Dodge
Historical warranty claims and technical repair bulletins for Dodge point to the following failure distribution:
3. Step-by-Step DIY Repair Guide for Dodge
Interface with the diagnostic port or system console using verified scanning hardware. Record freeze-frame data, active sub-codes, and timestamps to isolate whether P0671 is static or intermittent. on Dodge vehicles (Charger, Challenger).
Visually inspect the physical component (Cylinder 1 Glow Plug), connector pins, and associated wiring harnesses for signs of corrosion, thermal melting, or loose grounding clips. on Dodge vehicles (Charger, Challenger).
Measure reference voltages and resistance thresholds against manufacturer factory specifications. Replace any component failing nominal impedance tolerances. on Dodge vehicles (Charger, Challenger).
Install genuine OEM replacement hardware or execute registry / service commands. Ensure all mounting bolts are torqued to factory specifications. on Dodge vehicles (Charger, Challenger).
Erase the fault code from non-volatile memory. Perform a standard verification cycle (e.g. 15-minute mixed drive or system stress benchmark) to ensure monitors reset to 'Ready' state without recurrent fault flags. on Dodge vehicles (Charger, Challenger).
4. Dodge P0671 FAQs
What causes code P0671 to trigger on a Dodge?
On Dodge vehicles, P0671 is most frequently caused by Component aging, oxidation, or degraded internal circuit element (Cylinder 1 Glow Plug) or Wiring harness abrasion, loose terminal pin, or ground voltage float. Factory sensor degradation or wiring harness wear near the engine bay are common factors.
Can I safely drive my Dodge with code P0671?
Yes, for temporary operations. However, resolve promptly to maintain optimal efficiency and prevent cascade failures. Given that P0671 carries a Moderate severity rating on Dodge vehicles, we advise performing diagnostic scanning via the OBD-II port before extended driving.
How much does it cost to fix P0671 on a Dodge?
DIY replacement parts typically range between $100 - $250 (DIY: $20 - $50). If serviced at an authorized Dodge dealership, expect an additional $120–$250 in professional labor based on their $120/hr hourly rate.