FTC Reader Disclosure: When you purchase or register through links on our site, we may earn an affiliate commission at no extra cost to you. Read our Editorial & Advertising Policy.

P0455

Ford PlatformLow Severity

P0455 on Ford: Symptoms, Causes & DIY Fix

Official technical diagnostic wire for fault code P0455 (P0455: Evaporative Emission Control System Leak Detected (Gross Leak)) specifically affecting Ford vehicles (F-150, F-250 Super Duty, Explorer, Mustang, Escape, Bronco, Bronco Sport, Ranger, Maverick, Expedition, Mustang Mach-E).

DIY Parts Estimate

$15 - $250 (DIY: $15 - $50)

Ford OEM Direct Fit

Shop Labor Quote

$180 – $380

Based on $120/hr labor

Drivability Status

Drivable (Short Trip)

Low urgency level

Est. DIY Time

45 – 90 Min

Basic hand tools

Check P0455 On Another Make:

Toyota BMW Mercedes-Benz Lexus Ford Hyundai Cadillac Tesla Chevrolet Honda

1. Symptoms of P0455 on Ford

When the Engine Control Module (ECM/PCM) on your Ford logs fault code P0455, drivers commonly observe:

Check Engine Light on on Ford (F-150, F-250 Super Duty)

Gas cap loose warning message on dashboard on Ford (F-150, F-250 Super Duty)

Slight fuel vapor odor near rear of vehicle on Ford (F-150, F-250 Super Duty)

2. Most Likely Causes on Ford

Historical warranty claims and technical repair bulletins for Ford point to the following failure distribution:

55%

Missing, loose, or cracked gas cap seal (Ford OEM Part)

25%

Faulty EVAP purge control solenoid (Ford OEM Part)

12%

Stuck open EVAP vent valve (Ford OEM Part)

Cracked EVAP charcoal canister vapor hose (Ford OEM Part)

3. Step-by-Step DIY Repair Guide for Ford

Inspect and Tighten the Gas Cap

Remove gas cap, inspect rubber O-ring for cracks, tighten until it clicks 3 times. on Ford vehicles (F-150, F-250 Super Duty).

Required Tool: None

Replace Gas Cap with OEM Replacement

If the cap rubber is dried or cracked, replace with genuine OEM cap ($15). on Ford vehicles (F-150, F-250 Super Duty).

Required Tool: New OEM Gas Cap

Test EVAP Purge Solenoid Under Hood

Disconnect electrical plug and vacuum hose. Apply 12V; verify valve seals tight when unpowered. on Ford vehicles (F-150, F-250 Super Duty).

Required Tool: 12V Probe, Vacuum Pump

Inspect EVAP Canister Vent Valve Near Gas Tank

Check vent valve for road salt corrosion or spider nest clogs. on Ford vehicles (F-150, F-250 Super Duty).

Required Tool: Flashlight, Jack Stands

Smoke Test EVAP System

Pump mineral oil smoke into EVAP port to reveal any hairline cracked lines. on Ford vehicles (F-150, F-250 Super Duty).

Required Tool: EVAP Smoke Machine

4. Ford P0455 FAQs

What causes code P0455 to trigger on a Ford?

On Ford vehicles, P0455 is most frequently caused by Missing, loose, or cracked gas cap seal or Faulty EVAP purge control solenoid. Factory sensor degradation or wiring harness wear near the engine bay are common factors.

Can I safely drive my Ford with code P0455?

Yes. Completely safe to drive, but emissions test will fail. Given that P0455 carries a Low severity rating on Ford vehicles, we advise performing diagnostic scanning via the OBD-II port before extended driving.

How much does it cost to fix P0455 on a Ford?

DIY replacement parts typically range between $15 - $250 (DIY: $15 - $50). If serviced at an authorized Ford dealership, expect an additional $120–$250 in professional labor based on their $120/hr hourly rate.