P0420 on Dodge Charger: Symptoms, Causes & DIY Fix
Official technical diagnostic wire for fault code P0420 (P0420: Catalyst System Efficiency Below Threshold (Bank 1)) specifically affecting Dodge Charger vehicles equipped with 5.7L / 6.4L 392 HEMI / 6.2L Hellcat (717HP–797HP) / Hurricane 3.0L Turbo.
1. Symptoms of P0420 on Dodge Charger
When the Engine Control Module (ECM/PCM) on your Dodge Charger (5.7L / 6.4L 392 HEMI / 6.2L Hellcat (717HP–797HP) / Hurricane 3.0L Turbo) logs fault code P0420, drivers commonly observe:
2. Most Likely Causes on Dodge Charger
Historical warranty claims and technical repair bulletins for Dodge Charger point to the following failure distribution:
3. Step-by-Step DIY Repair Guide for Dodge Charger
Use a live-data scan tool. Downstream O2 sensor should show a steady voltage around 0.45V to 0.7V. If it fluctuates rapidly between 0.1V and 0.9V like the upstream sensor, the cat is not storing oxygen. on the Dodge Charger equipped with 5.7L / 6.4L 392 HEMI / 6.2L Hellcat (717HP–797HP) / Hurricane 3.0L Turbo.
Check exhaust manifold gaskets and flex pipes before the catalytic converter. Extra air entering exhaust false-triggers the P0420 code. on the Dodge Charger equipped with 5.7L / 6.4L 392 HEMI / 6.2L Hellcat (717HP–797HP) / Hurricane 3.0L Turbo.
If the sensor is sluggish or older than 100,000 miles, replace the downstream oxygen sensor first before condemning the expensive catalytic converter. on the Dodge Charger equipped with 5.7L / 6.4L 392 HEMI / 6.2L Hellcat (717HP–797HP) / Hurricane 3.0L Turbo.
Pour a designated catalytic cleaner (e.g. Cataclean) into 1/4 tank of fuel and drive 50 miles on the highway to burn off surface carbon deposits. on the Dodge Charger equipped with 5.7L / 6.4L 392 HEMI / 6.2L Hellcat (717HP–797HP) / Hurricane 3.0L Turbo.
If codes return after sensor replacement and cleaning, replace the catalytic converter with an EPA or CARB compliant unit. on the Dodge Charger equipped with 5.7L / 6.4L 392 HEMI / 6.2L Hellcat (717HP–797HP) / Hurricane 3.0L Turbo.
4. Dodge Charger P0420 FAQs
What causes code P0420 to trigger on a Dodge Charger?
On the Dodge Charger (5.7L / 6.4L 392 HEMI / 6.2L Hellcat (717HP–797HP) / Hurricane 3.0L Turbo), P0420 is most frequently caused by Catalytic converter internal substrate degraded or melted or Faulty Downstream Oxygen Sensor (O2 Sensor Bank 1 Sensor 2). Factory sensor degradation or wiring harness wear near the engine bay are common factors.
Can I safely drive my Dodge Charger with code P0420?
Yes for moderate distances, but vehicle will fail state emissions inspections. Given that P0420 carries a Medium severity rating on Dodge vehicles, we advise performing diagnostic scanning via the OBD-II port located driver lower dash assembly next to hood lever before extended highway driving.
Where is the diagnostic port located on the Dodge Charger?
The 16-pin OBD-II DLC connector on the Dodge Charger is situated driver lower dash assembly next to hood lever. It requires no special tools to plug in a standard scanner.
How much does it cost to fix P0420 on a Dodge Charger?
DIY replacement parts typically range between $400 - $1,800 (DIY: $150 - $400). If serviced at an authorized Dodge dealership, expect an additional $120–$250 in professional labor based on their $120/hr hourly rate.